Bryant ASPAS1BBL015 Bedienungshandbuch

Owner’s ManualONLY QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD ATTEMPTINSTALLATION!!DEADLY EXHAUST FUMES. OUTDOOR INSTALLATION ONLY!This manual shoul

8 Bryant1.14 ENGINE OIL RECOMMENDATIONSThe unit has been filled with 15W-40 engine oil at thefactory. Use a high-quality detergent oil classified “For

Bryant 9NOTE:It is essential to use the latest version of any stan-dard to ensure correct and current information.• NFPA No. 37, STATIONARY COMBUSTION

10 Bryant2.5 EMERGENCY CIRCUIT ISOLATIONMETHODThis prevents overloading the generator by keepingelectrical loads below the wattage/amperage capacityof

Bryant 112.10 BATTERY INSTALLATIONStandby generators installed with automatictransfer switches will crank and start automati-cally when NORMAL (UTILIT

12 BryantBefore starting the generator for the first time, theinstaller must complete the following procedures. Forfollow-up maintenance information a

Bryant 133.1.2 FAULT INDICATOR LAMPThe lamp goes ON when one or more of the followingengine faults occurs and when engine shuts down.• Low oil pressur

14 Bryant4.1 MAINTENANCE PERFORMED BY AUTHORIZED SERVICE FACILITIES A. EVERY THREE MONTHS1.Check battery state of charge and condition.2.Inspect and t

Bryant 154.4.2 BATTERY FLUIDCheck battery electrolyte fluid at least once a month.Fluid should cover separators in all battery cells. Iffluid level is

16 BryantFigure 4.2 - Oil FilterAfter refilling the crankcase with oil, alwayscheck oil level on dipstick. NEVER OPERATEENGINE WITH OIL BELOW THE DIPS

Bryant 17Finally, have the insulation resistance of stator androtor windings checked. If insulation resistances areexcessively low, the generator may

BryantINTRODUCTIONThank you for purchasing a Bryant home standbygenerator system.Every effort was expended to make sure that theinformation and instru

18 BryantSection 4 — MaintenanceBryant Liquid-cooled 15 kW Generators4.7 SCHEDULED MAINTENANCEThe following is a recommended maintenance schedule for

Bryant 19Section 4 — MaintenanceBryant Liquid-cooled 15 kW GeneratorsMaintenance Level 1 Level 2 Level 3 Level 4TasksRecom- Task Required Task Require

20 BryantSection 4 — MaintenanceBryant Liquid-cooled 15 kW GeneratorsMaintenance Level 1 Level 2 Level 3 Level 4TasksRecom- Task Required Task Require

Bryant 21Section 5 — TroubleshootingBryant Liquid-cooled 15 kW Generators5.1 TROUBLESHOOTING POINTSPROBLEM CAUSE CORRECTIONEngine won’t crank. 1. 15 a

Section 6 — NotesBryant Liquid-cooled 15 kW Generators22 Bryant

Bryant 23Section 7 - Installation DiagramBryant Liquid-cooled 15 kW GeneratorsDrawing No. 0E1533-B

2641144 RED11XX3333222211264411332225576TRANSFER SWITCHCONNECTION5464236713111214151618176352FOR PRE-PACK TRANSFER194SWITCH CONNECTIONS(BLACK)(BLACK)N

Bryant 25Section 8 - Electrical DataBryant Liquid-cooled 15 kW GeneratorsElectrical Schematic — Control Panel —Drawing No. 0F5244FL15GCU56117AB141643E

26 BryantSection 8 - Electrical DataBryant Liquid-cooled 15 kW GeneratorsWiring Diagram — 1.5L Engine — Drawing No. 0E0343-B0ELECTRONICCONTROLLERGOVER

Bryant 27Section 8 - Electrical DataBryant Liquid-cooled 15 kW GeneratorsElectrical Schematic — 1.5L Engine — Drawing No. 0A7182-CBWTS - WATER TEMPERA

Table of ContentsBryant Liquid-cooled 15 kW GeneratorsBryant 1INTRODUCTION ...IFCSAFETY RULES ...

ITEM PART NO. QTY. DESCRIPTION1098290 1 ASM MOTOR STEPPER2098941A 1 HOUSING GOVERNOR CONNECTOR3098958A REF CONNECTOR INTERFACE ASSEMBLY4098942A 1 COVE

ITEM PART NO. QTY. DESCRIPTION1 0D8656 1 BASE MOUNTING 1.5L STNRD & ACSTC2 027482 2 WASHER SHAKEPROOF EXT 5/16 STL3 070936 2 DAMPENER VIBRATION4 0

30 BryantNUTS ITEM #26.USE LOCTITE ONPANEL FOR ACCESSER CABLEWELD STUD UNDER ROOF17GROUND WIRE.FASTENER TO SECUREUSE DOOR LATCHNOTE:112471049242625198

ITEM PART NO. QTY. DESCRIPTION1 0D8666 1 ROOF ACSTC&STND CMPRTMNT 1.5L2 0D8664C 1 DUCT CENTER 1.5L3 0D8657 1 SUPPORT RADIATOR 1.5L MITSU4 0D8660 2

32 BryantSection 9 - Exploded Views and PartsBryant Liquid-cooled 15 kW GeneratorsControl Panel — Drawing No. 0F52402229265128262510273395867315034491

Bryant 33ITEM PART NO. QTY. DESCRIPTION10D9322 1 PANEL BACK & BOTTOM 20D9332 1 PANEL LH SIDE 3 0F5246A 1 PANEL FRONT W/SILKSCREEN40D9330 1 PANEL R

61WATERPUMPHARDWARE13910112871224101415166325412439413042424171110141119171820262120252224573311149247210111014124353436444514711246111049477011106692

ITEM PART NO. QTY. DESCRIPTION1 0A4531 1 ENGINE-1.5L2 022473 2 WASHER FLAT 1/4 ZINC3 057822 1 CLAMP HOSE #8 .53-1.004 0A45310258 1 GASKET-EXHAUST MANI

172128(BOTTOM ONLY)28"A"221511162"A"101911512143187641714TUBE (ON BLOCK)271310232619WATER INLET888208ADAPTER1224TO THERMOSTAT67Sec

ITEM PART NO. QTY. DESCRIPTION1 0D8657 1 SUPPORT RADIATOR 1.5L MITSU2 0A5734 1 RADIATOR 1.5L3 0A6237 1 VENTURI 1.5L MODINE4 * 0A6238 1 GUARD FAN 1.5L

Study these SAFETY RULES carefully before installing, operat-ing or servicing this equipment. Become familiar with thisOwner’s Manual and with the uni

38 Bryant43L.P. VAPORPORT"OUT 2"91340411110"D"1545212425302833201914"C"121716313266392638141403734363522"C"138

Bryant 39ITEM PART NO. QTY. DESCRIPTION1 * --------- 1 WELDMENT MOUNTING BASE2 075580 1 FLANGE FUEL INLET3 0E1006 1 ASSY REGULATOR 1.5L N.G.OR LPV4039

40 Bryant8361331259151417To BlowerHousing322324351212872233102916301826192031214To EngineCrankshaft26Section 9 - Exploded Views and PartsBryant Liquid

Bryant 41ITEM PART NO. QTY. DESCRIPTION1098671 1 ASSY ROTOR 10KW098681 1 ASSY ROTOR 15KW098675 1 ASSY ROTOR 20KW098936 1 ASSY ROTOR 25KW2 0A5336A 1 HO

ITEM PART NO. QTY. DESCRIPTION1 077483 REF BATT 12VDC 75-AH 26 (NOT INCLUDED)2 038804D 1 CABLE BATT RED #4 X 20.003 038805B 1 CABLE BATT BLK #4 X 23.0

Bryant 43ITEM PART NO. QTY. DESCRIPTION1 0A4355 1 MANIFOLD EXHAUST 1.5L2 0E2844 1 NIPPLE TOE 1.5NPTX5.5 BLK IRON3 036434 3 BOLT U 5/16-18 X 2.09036449

44 BryantSection 10 – WarrantyBryant Liquid-cooled 15 kW GeneratorsCALIFORNIA EMISSION CONTROL WARRANTY STATEMENTYOUR WARRANTY RIGHTS AND OBLIGATIONST

Bryant 45EMISSION CONTROL SYSTEM WARRANTYEmission Control System Warranty (ECS Warranty) for 1995 and later model year engines:(a) Applicability: This

Section 10 – WarrantyBryant Liquid-cooled 15 kW GeneratorsBRYANT "TWO YEAR" LIMITED WARRANTY FOR "PREPACKAGED EMERGENCY AUTOMATIC STAND

place before operating the generator. If work must be donearound an operating unit, stand on an insulated, dry surfaceto reduce shock hazard.• Do not

4 Bryant1.1 GENERATORThis equipment is a liquid-cooled, engine-driven gen-erator set. The generator is designed to supply elec-trical power that opera

Bryant 51.6 GENERATOR FUEL SYSTEMThe generator has been factory tested and adjustedusing a natural gas fuel system. If propane (LPrequirements) gas is

6 BryantFigure 1.6 - Low Coolant Level Sensor1.7.4 OVERSPEED SHUTDOWNThe Pre-pack circuit board on liquid cooled unitsreceives AC frequency (rpm) sign

1.10.2 ENGINE SPECIFICATIONSMake....................MitsubishiDisplacement .....